Change search
ReferencesLink to record
Permanent link

Direct link
Biochemical and microbiological properties of a cereal mix fermented with whey, wet wheat distillers' grain or water at different temperatures
Department of Animal Nutrition and Management, Swedish University of Agricultural Sciences, Uppsala, Sweden.
Department of Microbiology, Swedish University of Agricultural Sciences, Uppsala, Sweden.
Department of Microbiology, Swedish University of Agricultural Sciences, Uppsala, Sweden.
Department of Microbiology, Swedish University of Agricultural Sciences SLU, Uppsala, Sweden.
Show others and affiliations
2008 (English)In: Animal Feed Science and Technology, ISSN 0377-8401, E-ISSN 1873-2216, Vol. 144, no 1-2, 137-148 p.Article in journal (Refereed) Published
Abstract [en]

Microbiological and biochemical properties of three different liquid diets fermented at 10, 15 or 20 degrees C were studied. The liquid diets consisted of a cereal grain mix of wheat, barley and triticale, blended with whey (diet WH), wet wheat distillers' grain (diet WDG) or water (diet WAT). The diets were fermented for 5 days without disturbance, followed by 14 days of daily feed replacements, where 4/5 of the contents were replaced with fresh feed mixtures. Starting pH values were 5.1, 3.9 and 6.3 in WH, WDG and WAT, respectively. For most diets, the pH decreased to approximately 4.0 by day 5. However, the WAT diet fermented at 10 degrees C required 7 days to reach a pH of 4.0. A higher (P < 0.001) pH was seen in the WH diet fermented at 10 degrees C than in the other diets. Composition of the diets was determined during day 17-19 of fermnentation to allow the microbial populations to stabilise and to reflect conditions in practice. Lactic acid bacteria (LAB) grew in all diets during fermentation and the growth was affected by temperature and type of diet (P < 0.001), and the interaction between these two factors (P < 0.001). The highest LAB counts were found at higher temperatures in the WAT and WH diets and the lowest counts were found in diet WDG. The highest levels of acetic, succinic and propionic acids were found in diet WDG (P < 0.001). Lactic acid concentrations increased with temperature (P < 0.001) and were highest in the WAT and WH diets. In vitro digestibility of organic matter was highest for diet WH and lowest for diet WDG (P < 0.001). Inositol hexaphosphate-bound phosphorus (P) and total P in the cereal grain mix were 2.2 and 3.7 g kg(-1) dry matter, respectively. No inositol phosphate-bound P was found in any of the diets after fermentation. Some moulds, probably originating from spores in the cereal grain mix, were delected in the fermented diets, but total numbers did not increase with time. Enterobacteriaceae detected in diet WH, probably originated from the cereal grain mix and the whey. Yeasts were present in all diet ingredients. In conclusion, fermentation processes and biochemical properties differed greatly due to temperature, type of diet and the interaction of these two factors. Dietary inositol hexaphosphate was completely degraded in all fermented diets. (c) 2007 Elsevier B.V. All rights reserved.

Place, publisher, year, edition, pages
Amsterdam, Netherlands: Elsevier, 2008. Vol. 144, no 1-2, 137-148 p.
Keyword [en]
Pigs, liquid diets, fermentation, in vitro digestibility, feed microbiology
National Category
Food Science
URN: urn:nbn:se:oru:diva-52294DOI: 10.1016/j.anifeedsci.2007.09.028ISI: 000257486300010ScopusID: 2-s2.0-44649113798OAI: oai:DiVA.org:oru-52294DiVA: diva2:971992
Available from: 2016-09-19 Created: 2016-09-16 Last updated: 2016-09-19Bibliographically approved

Open Access in DiVA

No full text

Other links

Publisher's full textScopus

Search in DiVA

By author/editor
Schnürer, Johan
In the same journal
Animal Feed Science and Technology
Food Science

Search outside of DiVA

GoogleGoogle Scholar

Altmetric score

Total: 42 hits
ReferencesLink to record
Permanent link

Direct link